Forums Forums Enthusiast Forums A - Z Autowirral The Air Car

March 19, 2007 Many respected engineers have been trying for years to bring a compressed airhttp://en.wikipedia.org/wiki/Compressed_air car to market, believing strongly that compressed air can power a viable "zero pollutionhttp://en.wikipedia.org/wiki/Pollution " car. Now the first commercial compressed air car is on the verge of production and beginning to attract a lot of attention, and with a recently signed partnership with Tata, India’s largest automotive manufacturer, the prospects of very cost-effective mass production are now a distinct possibility. The MiniC.A.T is a simple, light urban car, with a tubular chassis that is glued not welded and a body of fibreglass. The heart of the electronic and communication system on the car is a computer offering an array of information reports that extends well beyond the speed of the vehicle, and is built to integrate with external systems and almost anything you could dream of, starting with voice recognitionhttp://en.wikipedia.org/wiki/Speaker_recognition , internet connectivity, GSM telephone connectivity, a GPS guidance system, fleet management systems, emergency systems, and of course every form of digital entertainment. The engine is fascinating, as is and the revolutionary electrical system that uses just one cable and so is the vehicle’s wireless control system. Microcontrollers are used in every device in the car, so one tiny radio transmitter sends instructions to the lights, indicators etc

There are no keys – just an access card which can be read by the car from your pocket.

Most importantly, it is incredibly cost-efficient to run – according to the designers, it costs less than one Euro per 100Km (about a tenth that of a petrol car). Its mileage is about double that of the most advanced electric carInnovation-At-Big-Companies Dec-07 (200 to 300 km or 10 hours of driving), a factor which makes a perfect choice in cities where the 80% of motorists drive at less than 60Km. The car has a top speedhttp://en.wikipedia.org/wiki/Top_Speed of 68 mph.

Refilling the car will, once the market develops, take place at adapted petrol stations to administer compressed air. In two or three minutes, and at a cost of approximately 1.5 Euros, the car will be ready to go another 200-300 kilometres.

As a viable alternative, the car carries a small compressor which can be connected to the mains (220V or 380V) and refill the tank in 3-4 hours.

Due to the absence of combustionhttp://en.wikipedia.org/wiki/Combustion and, consequently, of residues, changing the oil (1 litre of vegetable oilhttp://en.wikipedia.org/wiki/Vegetable_fats_and_oils ) is necessary only every 50,000 Km.

The temperature of the clean air expelled by the exhaust pipe is between 0 - 15 degrees below zero, which makes it suitable for use by the internal air conditioning system with no need for gases or loss of power.

How does it work?

90m3 of compressed air is stored in fibre tanks. The expansion of this air pushes the pistons and creates movement. The atmospheric temperature is used to re-heat the engine and increase the road coverage. The air conditioning system makes use of the expelled cold air. Due to the absence of combustion and the fact there is no pollution, the oil change is only necessary every 31.000 miles.